20-140 the oil cart

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 6:38 am

some of you know the story thus far, though i'd share the the pics

found way out west and used as a store/cart for diesel and oil drums in a quarry area- dave correct the story if you can...

had a tow rig hooked up at the front and the bulkhead had been cut for more storage room, engine removed the engine bay was now used as a tool box

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 6:44 am

as i first laid eyes on the old girl she appeared pretty solid, a big hit to the rear corner and some kids jumping on the roof didn't help but definately worth a closer look

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 6:57 am

unfortunately everything was coated in S^%t!

underneath covered in crusty mud and inside a treacle mixture of oil and diesel and dust, just a sticky sludge

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 7:05 am

got her home and started the process of scrubbing, and cleaning and scrubbing and cleaning...and on and on and on

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 7:11 am

the rear floor had been covered in 3mm steel plate so that had to come up- after cleaning to find the welds and fixings. The old floor and ibeams had been supported with 70x70 5mm angle iron and this had been used to replace both fron outriggers ad the cargo door sill

oh but first i had to clean some more!

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 7:13 am

and then the floor could come out - the original showing some pretty hard signs of graft but for the most part preserved by the oily mix that covered it

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 7:19 am

cuttting out the sections of steel angle was a mission but finally bits started going back in

sorry bout the crappy pics

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 7:41 am

all outriggers and jackpoints were done, and the usual tophat section- a little unusual over the sill fitting- not sure where i was heading there
inner and outer sills and both crossmembers, usual patches in chassis behind the outriggers and bottom b pillars as they had been mangled

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 7:43 am

like this shot - it was dark on the drive most of the time

the bus had been decommissioned and a road/track made next to it - the line of paint stripping down the side was friom the diesel filled blue metal that had been pushed up against the bus - left for another year or so there probably wouldnt have been much left!

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 7:48 am

bulkhead replacement thanks to Kombine and Cappo

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 7:56 am

unfortunately i was a bit useless when it came to taking pics - broke my phone in the process but got a few more along the way

wheelarches all cleaned up a treat - passenger inner dogleg and cab step ended up being rooted so had to fab that up

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 8:07 am

dash cleaned up real nice

cargo door bottoms had been bashed flat by the oil drums and cargo door aftermarket sill

managed to save the bottom of the rear one but the front was mangled

pathced the floor with some donor pieced from Dions DC - thanks mate

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 8:13 am

long sill only needed 3/4 repair that i still have to finish in the front, pass dogleg has a few pinholes that im slowly filling with weld to preserve paint as much as possible- was just going to let this weather
got the front beam in for trial fit too - good to have her back on wheels and moving out of the shed

resinmonkey · Post by **resinmonkey** » Sat Dec 10, 2011 8:20 am

Maiden voyage out of the shed - albeit not under her own power!

roof came up good with some remodelling and rear corner a sight better - still needs a bit of manipulation but i think i might call in some professional help to straighten it up a bit

KombiMadness · Post by **KombiMadness** » Sat Dec 10, 2011 9:12 am

Amazing clean up, Chris! You've saved her from a life of slavery & abuse

... and given a classic old girl a chance of a second life.